?液壓油一般可根據實際使用情況定期更換，一般使用兩年左右需更換一次；如需更換時應先將液壓油加入新油中充分?jǐn)嚢?，然后注入新油加滿油箱并加滿液壓油，最后打開氣閥將液壓油抽出，然后用清水沖洗油箱加油口，再將新?lián)Q的液壓油加入油箱并加滿液壓油。
若使用長時間不更換液壓油則會使油質變質，造成機器部件生銹、腐蝕、結垢、吸氫氣體等破壞失效形式，嚴重時還會引起泵管、葉片等部件早期磨損失效現象因此液壓油要根據使用情況及時更換每?jī)赡旮鼡Q一次液壓油為宜；長期使用液壓油粘度較低，且不易清除油污、臟物；而且對機械零件有腐蝕作用；如不能及時地將液壓油送回油箱或更換發動機潤滑系統中的易損件和部件；當液壓油粘度達到規定值時，就會發生潤滑不良或堵塞現象。
此時應將液壓油過濾干凈以便繼續使用使用超過2年后應重新加回油箱原牌號的液壓液若更換液壓油后仍不能將液壓液完全排出，也要重新加注新油，直至泵的運轉平穩為止 安裝前應檢查泵缸是否彎曲變形、活塞是否與缸體有間隙。
用手將活塞推動，若間隙過大，應立即調整活塞在缸體內不得有擺動活塞與缸體或缸套之間的密封圈應具有良好的密封性能應定期檢查冷卻水是否正常，并及時清除油底殼內液壓油中的水分和污物等冷卻水應該有足夠數量、溫度和壓力，以保持其質量，并且冷卻水必須有一定長度的流動范圍和壓力。
檢查液壓油是否缺少，并及時添加，以免發生液壓回路損壞或油泵漏油而損壞設備；清洗泵前的工作油缸、檢查并更換泵頭或閥體、安裝閥芯必要時更換密封圈，但其間隙不應超過額定間隙；若磨損嚴重而達不到規定要求時及時更換。
90R180-KA-5-NN-80-T-C-C8-J-09-NNN-35-35-28 90R180KA5NN80TCC8J09NNN353528 90-R-180-KA-5-NN-80-T-C-C8-J-09-NNN-35-35-28 90R180KA5NN80TCC8J09NNN353528 90R180-KA-5-NN-80-T-C-F1-H-00-FAC-23-23-28 90R180KA5NN80TCF1H00FAC232328 90-R-180-KA-5-NN-80-T-C-F1-H-00-FAC-23-23-28 90R180KA5NN80TCF1H00FAC232328 90R180-KA-5-NN-80-T-C-F1-J-03-FAC-20-20-22 90R180KA5NN80TCF1J03FAC202022 90-R-180-KA-5-NN-80-T-C-F1-J-03-FAC-20-20-22 90R180KA5NN80TCF1J03FAC202022 90R180-KA-5-NN-80-T-C-F1-J-03-FAC-35-35-22 90R180KA5NN80TCF1J03FAC353522 90-R-180-KA-5-NN-80-T-C-F1-J-03-FAC-35-35-22 90R180KA5NN80TCF1J03FAC353522 90R180-KA-5-NN-80-T-C-F1-J-05-FAC-20-20-24 90R180KA5NN80TCF1J05FAC202024 90-R-180-KA-5-NN-80-T-C-F1-J-05-FAC-20-20-24 90R180KA5NN80TCF1J05FAC202024 90R180-KA-5-NN-80-T-M-C8-H-03-NNN-20-20-26 90R180KA5NN80TMC8H03NNN202026 90-R-180-KA-5-NN-80-T-M-C8-H-03-NNN-20-20-26 90R180KA5NN80TMC8H03NNN202026 90R180-KA-5-NN-80-T-M-C8-H-03-NNN-26-26-24 90R180KA5NN80TMC8H03NNN262624 90-R-180-KA-5-NN-80-T-M-C8-H-03-NNN-26-26-24 90R180KA5NN80TMC8H03NNN262624 90R180-KA-5-NN-80-T-M-C8-J-03-NNN-32-32-24 90R180KA5NN80TMC8J03NNN323224 90-R-180-KA-5-NN-80-T-M-C8-J-03-NNN-32-32-24 90R180KA5NN80TMC8J03NNN323224 90R180-KA-5-NN-80-T-M-C8-J-03-NNN-35-35-30 90R180KA5NN80TMC8J03NNN353530 90-R-180-KA-5-NN-80-T-M-C8-J-03-NNN-35-35-30 90R180KA5NN80TMC8J03NNN353530 90R180-KA-5-NN-80-T-M-C8-J-03-NNN-42-42-24 90R180KA5NN80TMC8J03NNN424224 90-R-180-KA-5-NN-80-T-M-C8-J-03-NNN-42-42-24 90R180KA5NN80TMC8J03NNN424224 90R180-KA-5-NN-80-T-M-F1-H-03-FAC-23-23-24 90R180KA5NN80TMF1H03FAC232324 90-R-180-KA-5-NN-80-T-M-F1-H-03-FAC-23-23-24 90R180KA5NN80TMF1H03FAC232324 90R180-KA-5-NN-80-T-M-F1-J-03-FAC-20-20-22 90R180KA5NN80TMF1J03FAC202022 90-R-180-KA-5-NN-80-T-M-F1-J-03-FAC-20-20-22 90R180KA5NN80TMF1J03FAC202022 90R180-KA-5-NN-80-T-M-F1-J-03-NNN-38-38-24 90R180KA5NN80TMF1J03NNN383824 90-R-180-KA-5-NN-80-T-M-F1-J-03-NNN-38-38-24 90R180KA5NN80TMF1J03NNN383824 90R180-KA-5-NN-80-T-M-F1-J-05-NNN-38-38-24 90R180KA5NN80TMF1J05NNN383824 90-R-180-KA-5-NN-80-T-M-F1-J-05-NNN-38-38-24 90R180KA5NN80TMF1J05NNN383824。
